Product ID:00103 RUST BREAKER, A00103
MSDS Date:10/15/1997
FSC:8030
NIIN:00N080777
MSDS Number: CFSPP

SHERWIN-WILLIAMS DIVERSIFIED BRANDS INC

26300 FARGO AVE
BEDFORD HEIGHTS, OH 44146
US

Emergency Phone: 216-566-2917

Info Phone: 216-292-7400

Cage: DO642

SHERWIN-WILLIAMS DIVERSIFIED BRANDS INC

HOLLAND, MI 49423 US

Telephone: 615-392-7811

Cage: SHRWN

0.5.

CAS: 68551-20-2

Fraction By Weight: 82%

OSHA PEL N/K

ACGIH TLV: N/K

MINERAL OIL, PETRO DISTILLATES, SOLVENT-DEWAXED HEAVY

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 12%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 5 MG/M3 (MFR)

CALCIUM DINONYLNAPHTHALENE SULFONATE

CAS: 57855-77-3

Fraction By Weight: 2%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 3-5%

OSHA PEL 5000 PPM

ACGIH TLV: 5000 PPM;30000 STEL

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PPE. ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. IN CONFINED AREA VAPO RS IN HIGH CONCENTRATION
MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS. REDNESS AND ITCHING OR
BURNING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:MILDLY REFINED MINERAL OIL (CAS
#64742-65-0):IARC MONOGRAPHS, SUPPLEMENT, VOL 7, PG 252, 1987:GROUP
1.
Effects of Overexposure:HLTH HAZ:SENSATION MAY INDICATE EYE OR
EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDATTN.
INGEST:NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO
NOT INDUCE VOMITING. GIVE CONSCIOUS PATIENT SEVERAL GLASSES OF
WATER. SEEK MED ATTN.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS TO PREVENT PRESSURE BUILD-UP
& POSSIBLE AUTOIGNITIO N OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DOL STORAGE CATEGORY:1A. KEEP OUT OF
REACH OF CHILDREN. AVOID BREATHING VAPOR & SPRAY MIST. AVOID
CONTACT W/SKIN & EYES. USE ONLY W/ADEQUATE VENT.
Other Precautions:CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCIN/EXPOS TO
TEMPS >120F. HEAT FROM SUNLIGHT, RADIATORS, STOVES, HOT WATER &
OTHER HEAT SOURCES COULD CAUSE CNTNR TO BURST. DO NOT TAKE
INTERNALLY. ADDN OF RED UCERS/OTHER ADDITIVES TO THIS PRODUCT MAY
SUBSTANTIALLY ALTER COMPOSITION & HAZARDS OF PRODUCT.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED NIOSH
APPROVED ORGANIC VAPOR/PARTICULATE RESPIRATOR FOR PROTECTION
AGAINST INGREDIENTS.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS 1910.94,
1910.107, 1910.108.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:<550F,<288C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:0.83
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:87

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.

Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER RCRA (40 CFR 261). DO NOT INCINERATE. DEPRESSURIZE
CONTAINER. DISPOSE OF I/A/W FEDERAL, STATE & LOCAL REGULATIONS
REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.